Technological advances in a-Si: H/c-Si Heterojunction solar cells

Kamlesh Patel, Pawan K Tyagi

Abstract


Cost effective silicon-based thin-film solar cells have attained a sustainable age with stable in comparison to the crystalline silicon solar cells. The heterojunction solar cells based on amorphous silicon/crystalline silicon heterostructures are producing efficiency more than 22%. The research activities have led to such high efficiency through a number of technological developments. To make the surface passivation better at the top of c-Si substrate, a thin intrinsic a-Si: H layer is deposited in between the a-Si:H layer and c-Si substrate and such configuration has famous as Heterojunction with Intrinsic Thin-layer (HIT) solar cells. Various research methodologies used for the efficiency improvement in HIT cells have been developed in ages and now the HIT cells with efficiency better than 24% are being manufactured. The simultaneous developments of characterization methods well supported the improvements in fabrication technologies to analyze their self-governing effects on the deposited amorphous films, c-Si substrates and device performances. A number of characterization facilities have been established, which are based on the evaluation of effective carrier lifetime, density of interface states, recombination rate, cell efficiency, band offset, current density-voltage characteristics, charge carrier concentration, photoluminescence, activation energy etc.  The present paper reviews the fabrication technologies for the development of these reported solar cells and their characterizations as well at the material and device levels.


Keywords


Cell efficiency; heterojunction; HIT cell; PECVD; Thin film silicon

Full Text:

PDF

References


J. Carabe and J. J. Gandia, “Thin-film-silicon solar cells†, Opto-Electronics Review, vol. 12, pp. 1-6, 2004.

Y. J. Song, M. R. Park, E. Guliants, W. A. Anderson, “Influence of defects and band offsets on carrier transport mechanisms in amorphous silicon/crystalline silicon heterojunction solar cellsâ€, Solar Energy Materials & Solar Cells, vol. 64, pp. 225-240, 2000.

H.C. Neitzert, P. Spinillo, S. Bellone, G. D. Licciardi, M. Tucci, F. Roca, L. Gialanella, M. Romano, “Investigation of the damage as induced by 1.7MeV protons in an amorphous/crystalline silicon heterojunction solar cellâ€, Solar Energy Materials & Solar Cells, vol.83, pp. 435–446, 2004.

M. Tucci, G. de Cesare, “17% efficiency heterostructure solar cell based on p-type crystalline siliconâ€, Journal of Non-Crystalline Solids, vol. 338-340, pp.663–667, 2004.

C. Summonte, R. Rizzoli, D. Iencinella, E. Centurioni, A. Desalvo, F. Zignani, “Silicon heterojunction solar cells with microcrystalline emitterâ€, Journal of Non-Crystalline Solids, vol. 338–340, pp.706–709, 2004.

H.D. Goldbach, A. Bink, R. E. I. Schropp, “Thin p++ µc-Si layers for use as back surface field in p-type silicon heterojunction solar cellsâ€, Journal of Non-Crystalline Solids, vol. 352, pp.1872–1875, 2006.

J. D. Lacoste, P. Roca i Cabarrocas, P. Chatterjee, Y. Veschetti, A.S. Gudovskikh, J.P. Kleider, P.J. Ribeyron, “About the efficiency limits of heterojunction solar cellsâ€, Journal of Non-Crystalline Solids, vol. 352, pp.1928–1932, 2006.

K.v. Maydell, L. Korte, A. Laades, R. Stangl, E. Conrad, F. Lange, M. Schmidt, “Characterization and optimization of the interface quality in amorphous/crystalline silicon heterojunction solar cellsâ€, Journal of Non-Crystalline Solids, vol. 352, pp.1958–1961, 2006.

F. Wu¨nsch, G. Citarella, O. Abdallah, M. Kunst, “An inverted a-Si:H/c-Si hetero-junction for solar energy conversionâ€, Journal of Non-Crystalline Solids, vol. 352, pp.1962–1966, 2006.

Y. Xu, Z. Hu, H. Diao, Y. Cai, S. Zhang, X. Zeng, H. Hao, X. Liao, E. Fortunato, R. Martins, “Heterojunction solar cells with n-type nanocrystalline silicon emitters on p-type c-Si wafersâ€, Journal of Non-Crystalline Solids, vol. 352, pp.1972–1975, 2006.

W. Fuhs, L. Korte, M. Schmidt, “Heterojunctions of hydrogenated amorphous silicon and monocrystalline siliconâ€, Journal of Optoelectronics and Advanced materials, vol. 8, pp. 1989 – 1995, 2006.

U. K. Das, S. Bowden, M. Burrows, M. Lu, and R. W. Birkmire, “Effect of Surface Passivation on Si Heterojunction and Interdigitated Back Contact Solar Cellsâ€, the 17th Workshop on Crystalline Silicon Solar Cells & Modules: Materials and Processes, Vail, CO, 5 – 8 August 2007.

M. Edwards, S. Bowden, U. Das, M. Burrow, “Effect of texturing and surface preparation on lifetime and cell performance in heterojunction silicon solar cellsâ€, Solar Energy Materials & Solar Cells, vol. 92, pp.1373– 1377, 2008.

S. D. Wolf, S. Olibet and C. Ballif, “Stretched-exponential a-Si:H/c-Si interface recombination decayâ€, Applied Physics Letters, vol. 93, pp.032101-1-3, 2008.

I. Mora-Sero, Y. Luo, G. Garcia-Belmonte, J. Bisquert, D. Munoz, C. Voz, J. Puigdollers, R. Alcubillab, “Recombination rates in heterojunction silicon solar cells analyzed by impedance spectroscopy at forward bias and under illuminationâ€, Solar Energy Materials & Solar Cells, vol. 92, pp. 505–509, 2008.

H. Fujiwara, T. Kaneko, M. Kondo, “Optimization of interface structures in crystalline silicon heterojunction solar cellsâ€, Solar Energy Materials & Solar Cells, vol. 93, pp.725–728, 2009.

L. Korte, E. Conrad, H. Angermann, R. Stangl, M. Schmidt, “Advances in a-Si:H/c-Si heterojunction solar cell fabrication and characterizationâ€, Solar Energy Materials & Solar Cells, vol. 93, pp.905–910, 2009.

M. Losurdo, M. M. Giangregorio, G. V. Bianco, A. Sacchetti, P. Capezzuto, G. Bruno, “Enhanced absorption in Au nanoparticles/a-Si:H/c-Si heterojunction solar cells exploiting Au surface plasmon resonanceâ€, Solar Energy Materials & Solar Cells, vol. 93, pp.1749–1754, 2009.

R. Stangl, J. Haschke, M. Bivour, L. Korte, M. Schmidt, K. Lips, B. Rech, “Planar rear emitter back contact silicon heterojunction solar cellsâ€, Solar Energy Materials & Solar Cells, vol. 93, 1900–1903, 2009.

R. Barrio, J. J. Gandı´a, J.Ca´rabe, N. Gonza´lez, I. Torres, D. MunËœoz, C. Voz, “Surface recombination analysis in silicon-heterojunction solar cellsâ€, Solar Energy Materials & Solar Cells, vol. 94, pp.282–286, 2010.

M. Moreno, M. Labrune, P. Rocai Cabarrocas, “Dry fabrication process for heterojunction solar cells through in-situ plasma cleaning and passivationâ€, Solar Energy Materials & Solar Cells, vol. 94, pp.402–405, 2010.

A. Descoeudres, L. Barraud, R. Bartlome, G. Choong, S. D. Wolf, F. Zicarelli, and C. Ballif, “The silane depletion fraction as an indicator for the amorphous/crystalline silicon interface passivation qualityâ€, Applied Physics Letters, vol. 97, pp. 183505-1-3, 2010.

K. Ji, J. Choi, H. Yang, H. Lee, D. Kim, “A study of crystallinity in amorphous Si thin films for silicon heterojunction solar cellsâ€, Solar Energy Materials & Solar Cells, vol. 95, pp.203–206, 2011.

A. Descoeudres, L. Barraud, S. D. Wolf, B. Strahm, D. Lachenal et al, “Improved amorphous/crystalline silicon interface passivation by hydrogen plasma treatmentâ€, Applied Physics Letters, vol. 99, pp.123506-1-3, 2011.

J. Haschke, N. Mingirulli, R. Gogolin, R. Ferr´e, T. F. Schulze, J. D¨usterh¨oft, N. Harder and L. Korte, “Interdigitated Back-Contacted Silicon Heterojunction Solar Cells With Improved Fill Factor and Efficiencyâ€, IEEE Journal of Photovoltaics, vol. 1, pp.130-134, 2011.

M. Tanaka, M. Taguchi, T. Matsuyama, T. Sawada, S. Tsuda, S. Nakano, H. Hanafusa and Y. Kuwano, “Development of New a-Si/c-Si Heterojunction Solar Cells: ACJ-HIT (Artificially Constructed Junction-Heterojunction with Intrinsic Thin-Layer)â€, Japanese Journal of Applied Physics, vol. 31, pp. 3518-3522, 1992.

H. Sakata, T. Nakai, T. Baba, M. Taguchi, S. Tsuge, K. Uchihashi and S. Kiyama, “20.7% Highest efficiency large area (100.5cm2) HIT cellâ€, Photovoltaic Specialists Conference, Anchorage, AK , USA, pp. 7 – 12, 15 - 22 September 2000.

M. Tanaka, S. Okamoto, S. Tsuge and S. Kiyama, “Development of HIT solar cells with more than 21% conversion efficiency and commercialization of highest performance HIT modulesâ€, 3rd World Conference on Photovoltaic Energy Conversion, Osaka, Japan, pp. 955-958, 11-18 May 2003.

A.M. Froitzheim, M. L. D. Scherf, A. Ulyashin, Milch, M. Schmidt, W. R. Fahrne, W. Fuhs, “Amorphous/crystalline silicon heterojunction solar cells with intrinsic buffer layerâ€, 3rd World Conference on Photovoltaic Energy Conversion, Osab, Japan, pp.180-183, 11-18 May 2003.

M. Taguchi, A. Terakawa, E. Maruyama and M. Tanaka, “Obtaining a Higher Voc in HIT Cellsâ€, Prog. Photovoltaic: Res. Appl., vol. 13, pp. 481–488, 2005.

M. Garín, U. Rau, W. Brendle, I. Martín and R. Alcubilla, “Characterization of a-Si:H/c-Si interfaces by effective-lifetime measurementsâ€, Journal of Applied Physics, vol. 98, pp. 093711-1-9, 2005.

S. D. Wolf and M. Kondo, “Temperature dependent c-Si surface passivation properties of intrinsic PECVD a-Si:H filmsâ€, 16th Workshop on Crystalline Silicon Solar Cells and Modules: Materials and Processes, Denver, Colorado, pp.85-88, 6–9 August 2006.

M. Taguchi, E. Maruyama and M. Tanaka, “Temperature Dependence of Amorphous/Crystalline Silicon Heterojunction Solar Cells,†Japanese Journal of Applied Physics, vol.47, pp. 814–818, 2008.

S. K. Kim, J. C. Lee, S. J. Park, Y. J. Kim, K. H. Yoon, “Effect of hydrogen dilution on intrinsic a-Si:H layer between emitter and Si wafer in silicon heterojunction solar cellâ€, Solar Energy Materials & Solar Cells, vol. 92, pp. 298–301, 2008.

Y. Tsunomura, Y. Yoshimine, M. Taguchi, T. Kinoshita, H. Kanno, H. Sakata, E. Maruyama and M. Tanaka, “Twenty-two percent efficiency HIT solar cellâ€, Solar Energy Materials & Solar Cells, vol. 93, pp. 670-673, 2009.

Y. Hayashi and T. Nakamura, “Electrical Characteristics of an n-type Crystalline Si/i-n-type Amorphous Si:H Structureâ€, 16th Workshop on Crystalline Silicon Solar Cells & Modules: Materials and Processes, Denver, Colorado, pp.95-98, 6 – 9 August 2006.

H. Sakata, Y. Tsunomura, H. Inoue, S. Taira, T. Baba, H. Kanno, T. Kinoshita, M. Taguchi, and E. Maruyama, “R&D progress of next-generation very thin HIT solar cellsâ€, 25th European Photovoltaic Solar Energy Conference and Exhibition/5th World Conference on Photovoltaic Energy Conversion, Valencia, Spain, pp. 1102-1105, 6-10 September 2010.

L. Zhao, H. Diao, X. Zeng, C. Zhou, H. Li, W. Wang, “Comparative study of the surface passivation on crystalline silicon by silicon thin films with different structuresâ€, Physica B, vol. 405, pp. 61–64, 2010.

S. J. Lee, S. H. Kim, D. W. Kim, K. H. Kim, B. K. Kim, J. Jang, “Effect of hydrogen plasma passivation on performance of HIT solar cellsâ€, Solar Energy Materials & Solar Cells, vol. 95, pp. 81–83, 2011.

T. Mishima, M. Taguchi, H. Sakata, E. Maruyama, “Development status of high-efficiency HIT solar cellsâ€, Solar Energy Materials & Solar Cells, vol. 95, pp.18–21, 2011.

C. Y. Wei and C. H. Lin, “Applications of the Heterojunction with Intrinsic Thin Layer Solar-Cell Structure on Photodetectorsâ€, Japanese Journal of Applied Physics, vol.50, pp. 09MA04-1-3, 2011.

T. Kinoshita, D. Fujishima, A.Yano, A. Ogane, S. Tohoda, K. Matsuyama, Y. Nakamura, N. Tokuoka, H. Kanno, H. Sakata, M. Taguchi, E. Maruyama, “The approaches for high efficiency HIT solar cell with very thin (<100 mm) silicon wafer over 23%â€, the 26th EUPVSEC, pp.871–874, 2011.

A. Terakawa, H. Murayama, Y. Naruse, H. Katayama, T. Sekimoto, S. Yata, M. Matsumoto, I. Yoshida, M. Hishida, Y. Aya, M. Iseki, M. Taguchi and M. Tanaka, “Panasonic’s Thin film silicon technologies for Advanced photovoltaicsâ€, MRS conference, vol. 1536, pp. mrss13-1536-a02-01, 2013.

Mikio Taguchi, Ayumu Yano, Satoshi Tohoda, Kenta Matsuyama, Yuya Nakamura, Takeshi Nishiwaki, Kazunori, “24.7% Record Efficiency HIT Solar Cell on Thin Silicon Waferâ€, IEEE Journal Of Photovoltaics, vol.4, no.1, pp. 96-99, 2013.

P. Campbell and M. Keevers, “Light Trapping and Reflection Control for Silicon Thin Films Deposited on Glass Substrates Textured by Embossingâ€, 28th IEEE Photovoltaic Specialists Conference, Anchorage, pp. 355-358, 2000.

Tom Markvart and Luis Castaner, Solar cells: Materials, Manufacture and Operation, Elsevier, 2007.

C. Beneking,B. Rech, S. Wieder, O. Kluth, H. Wagner, W. Frammelsberger, R. Geyer, P. Lechner, H.Rubel, H. Schade, "Recent developments of silicon thin film solar cells on glass substrates", Thin Solid Films, vol. 351, pp. 241-246, 1999.

A. V. Shah, R. Platz, and H. Keppner, “Thin-film silicon solar cells: a review and selected trendsâ€, Solar Energy Materials & Solar Cells, vol. 38, pp. 501–520, 1995.




DOI (PDF): https://doi.org/10.20508/ijrer.v4i2.1323.g6308

Refbacks

  • There are currently no refbacks.


Online ISSN: 1309-0127

Publisher: Gazi University

IJRER is cited in SCOPUS, EBSCO, WEB of SCIENCE (Clarivate Analytics);

IJRER has been cited in Emerging Sources Citation Index from 2016 in web of science.

WEB of SCIENCE in 2025; 

h=35,

Average citation per item=6.59

Last three Years Impact Factor=(1947+1753+1586)/(146+201+78)=5286/425=12.43

Category Quartile:Q4